Poulan 184617 Bedienungsanleitung

OWNER'S MANUALMODEL:PD20H42STALAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION WARNING:Read this Owner's Man u al and foll

10OPERATIONKNOW YOUR TRACTORREAD THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTORCompare the illustrations with your tractor to

11OPERATIONThe operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safe

12OPERATIONTO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes greater than 15° and do not drive across any slope.• Choose th

13OPERATIONTO START ENGINE (See Fig. 5)When starting the engine for the fi rst time or if the engine has run out of fuel, it will take extra cranking t

14FIG. 10 MOWING TIPS• Mower should be properly leveled for best mowing per-formance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustment

15MULCHING MOWING TIPSIMPORTANT: FOR BEST PERFORMANCE, KEEP MOWER HOUSING FREE OF BUILT-UP GRASS AND TRASH. CLEAN AFTER EACH USE.• The spe cia

16MAINTENANCEBEFORE EACH USETRACT0RInspect Muffler/Spark ArresterLubrication ChartCheck Brake OperationClean Air FilterChange Engine Oil (with oil fil

17MAINTENANCEBLADE REMOVAL (See Fig. 12)• Raise mower to highest position to allow access to blades.• Remove blade bolt, lock washer and fl at

18MAINTENANCEV-BELTSCheck V-belts for deterioration and wear after 100 hours of operation and replace if necessary. The belts are not ad just able. Re

19MAINTENANCEMUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age.SPARK PLU

2DO NOT:• Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible.• Do not mow near drop-offs, dit

20SERVICE AND ADJUSTMENTSWARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SER VICE OR AD JUST -MENTS• Depress clutch/brake pedal fully and set

21SERVICE AND ADJUSTMENTSNUT "E""D""D"MANDRELFIG. 21NUT "F"FRONT LINKSFIG. 22FRONT-TO-BACK ADJUSTMENT (See Fig

22SERVICE AND ADJUSTMENTSFIG. 23TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 23)The mower blade drive belt may be replaced without tools. Park the tra

23SERVICE AND ADJUSTMENTSTO REMOVE WHEEL FOR REPAIRS (See Fig. 27)• Block up axle securely.• Remove axle cover, retaining ring and washer

24SERVICE AND ADJUSTMENTSFIG. 29FIG. 30TO REPLACE HEADLIGHT BULB• Raise hood.• Pull bulb holder out of the hole in the backside of the grill.

25ENGINETO AD JUST THROTTLE CON TROL CABLE (See Fig. 32)The throttle control has been preset at the factory and ad just ment should not be necessary.

26STORAGEImmediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more.WARNING: Never

27PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTSWill not start 1. Out of fuel.

28PROBLEM CAUSE CORRECTION TROUBLESHOOTING POINTSEngine continues to run 1. Faulty operator-safety presen

29BATTERYFUSEIGNITIONSWITCHREDREDREDBLACKIGNITIONUNITHEADLIGHTSREMOVABLECONNECTIONSBLACKBLACKBLACKWHITEWHITEWHITEREDBLACKORANGEBLACKBROWNBLACKBLACKBLA

3WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark pl

30TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09ELECTRICAL 2829262442432727254127274033903082127D.C. AMPERES451622215216

31TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09ELECTRICAL KEY PARTNO. NO. DESCRIPTION1 144927

32TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09CHASSIS 262558642081320811132920820920955207333142333142145373372426252093124303532

33TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09CHASSIS KEY PART NO. NO. DESCRIPTION1 1746

34TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09DRIVE 66292832305232593861415335553662353622393416177 7730525664652126311670579626251

35TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09DRIVE KEY PARTNO. NO. DESCRIPTIONKEY PARTNO. NO.

36TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09STEERING ASSEMBLY 5543436438104032118687464686872988711743912141423736373812394451

37TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09STEERING ASSEMBLY KEY PARTNO. NO. DESCRIPTION1 180656

38TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09SEAT ASSEMBLY 1 171683 Seat2 140551 Bracket Pivo

39TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09DECALS NOTE: All component dimensions given in U.S. inches 1 inch = 25.4

4GASOLINE CAPACITY 2.0 GALLONSAND TYPE: UNLEADED REGULAROIL TYPE (API-SF-SJ): SAE 30 (above 32°F) SAE 5W-30

40TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09ENGINE 143821OPTIONAL EQUIPMENTSpark Arrester2910657213262548171617381234544463231333

41TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09ENGINE KEY PART NO. NO. DESCRIPTIONNOTE: All compo

42151413111098166830313233146148145150451441471471421491425452535556341464421242526272282923212121181820248591943562140143364037401591403718442_deck_m

43TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09MOWER DECK KEY PART NO. NO. DESCRIPTIONKEY PART

44TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09MOWER LIFT 3615201617182020152045623165473741403812113132313219191313131323242527282

45TRACTOR - - MODEL NUMBER PD20H42STA PRODUCT NO. 954 56 95-09MOWER LIFT 1 184432 Wire Asm Inner/Sprg W/plunger LT2 1594

46LIMITED WARRANTYThe Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als an

4715 DEGREES MAX.FOLD ALONG DOTTED LINETHIS IS A 15 DEGREE SLOPEONLY RIDE UP AND DOWN HILL,NOT ACROSS HILLSUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE

Your POULAN PRO product has been expertly en gi neered and carefully manu fac tured to rigid quality stan dards. As with all mechanical products

5UNASSEMBLED PARTS(1) Large Flat WasherSteering Wheel InsertSteering SleeveSteering Wheel(1) Knob(1) Washer 17/32 x 1-3/16 x 12 GaugeSeat(2) Mulch Bl

6ASSEMBLYTOOLS REQUIRED FOR ASSEMBLYA socket wrench set will make assembly easier. Stan dard wrench sizes are listed.Utility knife Pliers(1) 3/

7ASSEMBLYFIG. 2SEAT PANSHOULDER BOLTADJUSTMENT KNOBFLAT WASHERSEATFIG. 3HOW TO SET UP YOUR TRACTORINSTALL SEAT (See Fig. 2)Adjust seat before tighteni

8ASSEMBLY✓CHE CKLISTBEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PERFORMANCE AND SATISFACTION FROM TH

9OPERATIONThese symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing.DANGER, KEEP HANDS